![Reply](http://www.njfboa.org/forums/images/buttons/reply.gif) |
02-19-2017, 05:06 PM
|
#1
|
Stalker
Join Date: Aug 2004
Posts: 12,077
|
How to diagnose bad Torque Convertor vs. bad transmission?
How can I tell if the problems I'm experiencing is related to a bad TQ convertor or a bad transmission?
Vehicle is a 1996 Dodge ram, 2wd, 5.9L I6 12valve Cummins turbo diesel. 77k miles. (Trans was already rebuilt at 30k miles) (Less than 5k miles in past 5 years)
Several months ago, maybe even going back to last winter, when I'd drive the truck maybe 4-5 times a month, the first thing I noticed was that when I started it up and put it in reverse, it would not move. I'd then have to lightly rev it up a few times and then the trans would seem to engage and it would reverse out of the driveway. After that it would drive fine, forward and reverse. It only did that if it sat for a period of time, which was usually 1-2 weeks.
Then back around September or so, while driving it seemed to occasionally have issues with overdrive. At speeds between 45-55, it would almost feel like it would upshift and downshift randomly. When I would accelerate around those speeds, sometimes it would shift up normally, other times it would hang in a lower gear until I let of the throttle, then it would upshift fine on its own.
Now this morning, I had to sightly feather the throttle to reverse, even though I drove it just yesterday with no issues. So then I went to the store and stopped at a stop sign in the parking lot. When I tried to move again, it felt like the truck was in neutral. Nothing at all. But 2-3 seconds later the trans engaged again and I was able to drive fine. I parked, got breakfast, and the truck acted normal backing up and leaving the parking lot. However, once again at speeds 45-55 it seemed to get confused about overdrive again. I got to where I was going and checked the fluid, it was actually overfilled by a decent amount. I know it was at the proper level(hot, running in idle) back over the summer and no one else had touched it since.
I'm wondering if the transmission itself is shot, just the torque convertor or maybe its the valve body. Any idea how to diagnose it a little better?
The issues were never really consistent so taking it to a trans shop would be hit or miss, plus I no longer know of any good trans shops. All the ones now just seem to say you need a full trans rebuild no matter what. Perhaps taking it to a diesel specific shop would be the best idea. I've read that bad grounds or a faulty TPS could possibly cause trans issues on these Rams. If I do need any new parts, I will not go with stock since I do plan to increase my HP level eventually and I know the stock trans wouldn't survive that anyway.
|
|
|
02-19-2017, 05:20 PM
|
#2
|
Mongo the Meet Coordinator
Join Date: May 2008
Posts: 16,900
|
Get a trans pressure gauge, run the line into the cab and start recording numbers for PRNDL etc. IDK what that trans calls for in each gear but you should be able to get a baseline somewhere online.
That will get you more specific direction.
__________________
Quote:
Originally Posted by KirkEvil
repo bigals turd gen and part it out to a loving home
|
|
|
|
02-19-2017, 08:14 PM
|
#3
|
Power Member / trans break does not equal transbrake
Join Date: May 2009
Location: The Meadowlands
Posts: 4,513
|
I could be wrong, but I believe the Converters were weak on those specific trucks. My buddy had a dually that had trans issues but after swapping the converter out for another it seemed to fix the issue.
__________________
99 Z28 - SBE LS1/60e
Motor - 10.84 @ 128 - 1.47 60'
Nitrous - 10.16 @ 132 - 1.40 60"
|
|
|
02-19-2017, 08:44 PM
|
#4
|
12 Second Club
Join Date: Aug 2004
Location: Oradell
Posts: 8,368
|
my blazer is doing everything u have described lol. i had the filter and fluid changed and it got a little better. i have about 35k on its rebuild also.
i was thinking its about time to remove and clean the throttle body and related sensors, its been quite a few years since that was last done, and has 178k miles now
__________________
86 Camaro
88 Camaro
95 Impala SS
97 Trans Am WS6
98 Blazer ZR2
00 Corvette
04 CTS-V
07 Sublime Charger Daytona
10 Tahoe SSV
12 Tahoe LT
17 Malibu LT
|
|
|
02-22-2017, 12:07 PM
|
#5
|
Stalker
Join Date: Aug 2004
Posts: 12,077
|
Well on monday and tuesday it drove basically like normal. I did experience a high rpm(~2600) 1-2 shift at full throttle off a light but not sure if that is normal or not. Also seems the convertor lockup speed happens to be around 50 mph so thats part of the issue I think im seeing driving on this one road where I vary between 45 and 55. I do still feel there is some real issue still going on, but I dont feel its really major or possibly even mechanical at this point. I almost have to drive it just until it fails completely and then I'll know better whats wrong.
Last edited by V; 02-22-2017 at 12:08 PM.
|
|
|
04-01-2017, 01:38 AM
|
#6
|
12 Second Club
Join Date: Aug 2004
Location: Oradell
Posts: 8,368
|
unknown if related, but i had my fuel pump replaced, and the battery was disconnected at this time, since getting it back ive only had this occur once and it was very minor.
__________________
86 Camaro
88 Camaro
95 Impala SS
97 Trans Am WS6
98 Blazer ZR2
00 Corvette
04 CTS-V
07 Sublime Charger Daytona
10 Tahoe SSV
12 Tahoe LT
17 Malibu LT
|
|
|
04-01-2017, 08:10 AM
|
#7
|
Stalker
Join Date: Aug 2004
Posts: 12,077
|
Well, one thing that I've read online that could be a cause is a dirty ground. I have yet to do anything about my issue yet. It seems to be ok most of the time. Hasn't free-reved since that one time and reverses like normal too now. Still gets confused around 45-50 with down shifting and upshifting. I may try a fluid/filter change and see if that helps. But yes, i also want to disconnect the batteries and clean the terminals/chassis grounds. I start a new job Monday and will be working at least 6 days a week so time to do anything will be limited.
Last edited by V; 04-01-2017 at 08:12 AM.
|
|
|
04-01-2017, 10:31 PM
|
#8
|
12 Second Club
Join Date: Aug 2004
Location: Oradell
Posts: 8,368
|
Quote:
Originally Posted by V
Well, one thing that I've read online that could be a cause is a dirty ground. I have yet to do anything about my issue yet. It seems to be ok most of the time. Hasn't free-reved since that one time and reverses like normal too now. Still gets confused around 45-50 with down shifting and upshifting. I may try a fluid/filter change and see if that helps. But yes, i also want to disconnect the batteries and clean the terminals/chassis grounds. I start a new job Monday and will be working at least 6 days a week so time to do anything will be limited.
|
Ha i know the feeling. i have 3 days off in all of april.
__________________
86 Camaro
88 Camaro
95 Impala SS
97 Trans Am WS6
98 Blazer ZR2
00 Corvette
04 CTS-V
07 Sublime Charger Daytona
10 Tahoe SSV
12 Tahoe LT
17 Malibu LT
|
|
|
04-02-2017, 01:22 PM
|
#9
|
Join Date: Jun 2016
Location: Millstone
Posts: 142
|
I know those trans' for those trucks suck. Had a couple friends blow them up in that body style.
|
|
|
04-02-2017, 02:12 PM
|
#10
|
Stalker
Join Date: Aug 2004
Posts: 12,077
|
Quote:
Originally Posted by DirtyBird
I know those trans' for those trucks suck. Had a couple friends blow them up in that body style.
|
Yes they do suck, lol. Basically all dodge transmissions in general too.
That's why when it blew with just 30k miles, we had a private shop rebuild it instead of going back to Dodge for warranty. The shop did some upgrades as far as I can remember, but the guys were getting old and they closed for business many years ago.
|
|
|
08-17-2019, 12:00 PM
|
#11
|
Stalker
Join Date: Aug 2004
Posts: 12,077
|
So here's somewhat of an update:
I have not done any work or diagnostics of the truck yet but a few weeks back, I was watching some automotive tv show, possibly "Truck U", and they were discussing the vacuum system on diesel trucks. They were saying how diesel motors don't create vacuum like gas engine and require a vacuum pump to operate the brakes and other components. I also do believe they mentioned something in regards to the transmission in Dodges about being somewhat vacuum controlled. The more I thought about it, I realized it takes a little bit after I start the truck in order to get the power brakes working right since there's no vacuum apparently after sitting for extended periods of time. So today when I took the truck out, it would not engage reverse right away and instead of revving it a few times like i usually do, I just let it idle for maybe 10 seconds. When I let off the brake then, it started reversing like normal. So its seems my issue is most likely related to a slow vacuum leak that is only seen when the truck sits for a week or so. That is easily something I can deal with and accept without worrying about trying to fix it anytime soon. For now, I'm just glad that it doesn't appear to be a mechanical issue.
|
|
|
01-26-2021, 07:53 PM
|
#12
|
Stalker
Join Date: Aug 2004
Posts: 12,077
|
Another update....
Apparently its a very common dodge truck issue. I finally ended up searching the correct terms and got more than enough results to numerous threads online with the exact issue. The common suggested fix was to first shift into reverse or drive, and then let the truck run at least 10-15 seconds before letting off the brake and driving away. Something about the pump not building pressure in park normally, i dunno, but its not just me having this problem. And its more common with those who don't drive the truck for days/weeks at a time, exactly like me.
So for now, this problem is solved.
...now to look into the Killer Dowel Pin, and my strange turbo whine....
|
|
|
01-27-2021, 04:08 AM
|
#13
|
11 second club / Moderator
Join Date: Aug 2004
Location: West Berlin, NJ
Posts: 7,148
|
Is it a 47re? I thought they had converter drain back issues that caused the delay initial shift out of park.
And they dont pump in park either, do they? Try starting it up and put it in neutral with the brake on and let it idle and see if that helps
__________________
2001 Trans Am WS6 •SLP Loudmouth II •UMI Suspension •12.857 @ 109.57
1996 Trans Am WS6 •Pacesetter Longtubes •Strange 12 Bolt •Spohn Suspension •11.152 @ 123.85
Last edited by deadtrend1; 01-27-2021 at 08:05 AM.
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
|
|